Axial Compression Performance of Slender Concrete-Filled Circular Steel Tubular Column with Pitting Corrosion Damage

Jianwei Li; Lanlan Wang; Chen Jia; Lanhui Guo

doi:10.13206/j.gjgS23111502

Volume 39 Issue 7

Jul. 2024

Turn off MathJax

Article Contents

Abstract

References

Article Navigation > STEEL CONSTRUCTION(Chinese & English) > 2024 > 39(7): 47-54

Jianwei Li, Lanlan Wang, Chen Jia, Lanhui Guo. Axial Compression Performance of Slender Concrete-Filled Circular Steel Tubular Column with Pitting Corrosion Damage[J]. STEEL CONSTRUCTION(Chinese & English), 2024, 39(7): 47-54. doi: 10.13206/j.gjgS23111502

Citation:

Jianwei Li, Lanlan Wang, Chen Jia, Lanhui Guo. Axial Compression Performance of Slender Concrete-Filled Circular Steel Tubular Column with Pitting Corrosion Damage[J]. STEEL CONSTRUCTION(Chinese & English), 2024, 39(7): 47-54. doi: 10.13206/j.gjgS23111502

Citation:

PDF( 8424 KB)

Axial Compression Performance of Slender Concrete-Filled Circular Steel Tubular Column with Pitting Corrosion Damage

doi: 10.13206/j.gjgS23111502

1. School of Civil Engineering, Harbin Insitute of Technology, Harbin 150090, China;
2. Jilin Research and Design Institute of Building Science, Changchun 130011, China

Received Date: 2023-11-15
Available Online: 2024-08-16

Abstract

Abstract

Localized pitting corrosion damage can cause an adverse impact on the safety of concrete-filled steel tubes (CFST). This paper conducted a numerical analysis of the axial compression performance of slender CFST with pitting corrosion damage. The failure phenomenon and load-deformation relationships from the existing tests were used to verify the numerical models. Then, the verified models were extended to take the random characteristics of corrosion pits in the aspect of distribution, dimensions, and locations into account. The influence of the degree of local volume loss, material strength, and slenderness ratio on the load-deflection curves was analyzed. According to the same degree of local volume loss, the CFST with equivalent thickness loss was established. The different influences of pitting corrosion and equivalent local defect on the ultimate strength were compared. Finally, based on the equivalent thickness loss, three methods based on the Chinese codes were put forward and to calculate the axial compression performance of CFST column with pitting corrosion damage and compare with the result of FE analysis.
The results show that the influence caused by different distributions of corrosion depth could be ignored. Compared with the equivalent local defect, the pitting corrosion can have a greater decrease in the ultimate strength of the slender CFST. According to the degree of local volume loss, the methods based on GB 50936- 2014 could predict the ultimate strength of CFST with pitting corrosion damage, and the method based on GB 50936-2014 could provide a prediction with good accuracy and moderate consideration.
- concrete-filled circular steel tubular,
- random pitting corrosion,
- axial compression performance,
- finite element analysis

FullText(HTML)

References(25)

References

[1]	Han L H, Hou C C, Wang Q L. Behavior of circular CFST stub columns under sustained load and chloride corrosion[J]. Journal of Constructional Steel Research, 2014,103(12):23-36.
[2]	Hou C C, Han L H, Wang Q L, et al. Flexural behavior of circular concrete filled steel tubes (CFST) under sustained load and chloride corrosion[J]. Thin-Walled Structures, 2016, 107:182-196.
[3]	贾晨,邵永松,郭兰慧,等.建筑结构用钢的大气腐蚀模型研究综述[J].哈尔滨工业大学学报, 2020,52(8):1-9.
[4]	Guo L, Huang H, Jia C, et al. Axial behavior of square CFST with local corrosion simulated by artificial notch[J]. Journal of Constructional Steel Research, 2020,174,106314.
[5]	Yuan F, Chen M, Huang H, et al. Circular concrete filled steel tubular (CFST) columns under cyclic load and acid rain attack:test simulation[J]. Thin-Walled Structures, 2018, 122(1):90-101.
[6]	Xie L, Chen M C, Sun W, et al. Behaviour of concrete-filled steel tubular members under pure bending and acid rain attack:test simulation[J]. Advances in Structural Engineering, 2019,22(1):240-253.
[7]	Han L H, Hua Y X, Hou C, et al. Circular concrete-filled steel tubes subjected to coupled tension and chloride corrosion[J]. Journal of Structural Engineering, 2017,143(10),04017134.
[8]	Hua Y X, Han L H, Wang Q L, et al. Behaviour of square CFST beam-columns under combined sustained load and corrosion:experiments[J]. Thin-Walled Structures, 2019,136:353-366.
[9]	Guo L H, Li J W, Jia C, et al. Axial compression behavior of slender concrete-filled steel tubes with machining defects representing local corrosion[J]. Engineering Structures, 2023, 286,116091.
[10]	Huang H, Guo L, Qu B, et al. Tests of circular concrete-filled steel tubular stub columns with artificial notches representing local corrosions[J]. Engineering Structures, 2021,242(8),112598.
[11]	Zhong L, Guo L, Jia C. Axial compression behavior of stub square concrete-filled steel tubes with regional defect[J]. Engineering Structures, 2023,278,115510.
[12]	Lin S Q, Li Z L, Zhao Y G. Behavior of eccentrically loaded circular concrete-filled steel tube stub columns with localized corrosion[J]. Engineering Structures, 2023,288,116227.
[13]	李振林,林思奇,赵衍刚,等.局部腐蚀钢管混凝土短柱轴压性能试验研究[J].工程力学, 2023,40(8):170-180.
[14]	Luo S, Chen M, Huang H, et al. Eccentric compression test and ultimate load strength analysis of circular CFST long column with local corrosion[J]. Structures, 2023,56,104937.
[15]	Li G, Hou C, Shen L. Combined compression-bending performance and design of CFST with localised pitting corrosion[J]. Journal of Constructional Steel Research, 2022,192,107247.
[16]	Tao Z, Wang Z, Yu Q. Finite element modelling of concrete-filled steel stub columns under axial compression[J]. Journal of Constructional Steel Research, 2013,89:121-131.
[17]	王文静,耿焘,贾晓楠,等.腐蚀对结构受力的影响以及改进措施[J].中国工程机械学报, 2014(2):118-122.
[18]	Nakai T, Matsushita H, Yamamoto N. Effect of pitting corrosion on strength of web plates subjected to patch loading[J]. ThinWalled Structures, 2006,44(1):10-19.
[19]	Rivas D, Caleyo F, Valor A, et al. Extreme value analysis applied to pitting corrosion experiments in low carbon steel:comparison of block maxima and peak over threshold approaches[J]. Corrosion Science, 2008,50(11):3193-3204.
[20]	张威.锈蚀钢筋表面特征的统计分析及其力学性能退化模型研究[D].西安:西安建筑科技大学, 2013.
[21]	Nakai T, Matsushita H, Yamamoto N, et al. Effect of pitting corrosion on local strength of hold frames of bulk carriers (1st report)[J]. Marine Structures, 2004,17(5):403-432.
[22]	Nakai T, Matsushita H, Yamamoto N. Effect of pitting corrosion on local strength of hold frames of bulk carriers (2nd report):lateral-distortional buckling and local face buckling[J]. Marine Structures, 2004,17(8):612-641.
[23]	中华人民共和国住房和城乡建设部.钢管混凝土结构技术规范:GB 50936-2014[S].北京:中国建筑工业出版社,2014.
[24]	中国工程建设标准化协会.钢管混凝土结构技术规程:CECS 28:2012[S].北京:中国计划出版社,2012.
[25]	福建省住房和城乡建设厅.钢管混凝土结构技术规程:DBJ/T 13-51-2010[S].福州:福建省住房和城乡建设厅,2010.

Relative Articles

[1]	Zhenghao Qian, Weiyong Wang. Research on Mechanical Properties of Circular Tubed Steel-Reinforced Concrete Stub Columns with High-Strength Steel Under Axial Compression[J]. STEEL CONSTRUCTION(Chinese & English), 2025, 40(2): 29-36. doi: 10.13206/j.gjgS24091402
[2]	Yanxia Zhang, Tianhao Shi, Binglong Wu, Zhengqi Lin. Comparisons of Seismic Performance of Fully-Bolted Column Joints of Steel Tubular Columns with Built-in Cross-Shaped Core Barrels and Built-in Octagonal Core Tube[J]. STEEL CONSTRUCTION(Chinese & English), 2024, 39(12): 38-48. doi: 10.13206/j.gjgS24011101
[3]	Zuowei Qin, Hui Li, Dong Han, Haiqiang Jiang. Structure Optimization and Performance Analysis of Box-Type Support Joint of L-Shaped Partially Coated Steel-Concrete Composite Column[J]. STEEL CONSTRUCTION(Chinese & English), 2024, 39(6): 7-13. doi: 10.13206/j.gjgS22082301
[4]	Guochang Li, Lirong Wei, Zengmei Qiu, Xu Liu. Seismic Fragility Analysis of High-Strength Concrete Filled Steel Tube Column-Aluminum Alloy Buckling Restrained Braces Structure System[J]. STEEL CONSTRUCTION(Chinese & English), 2024, 39(7): 1-9. doi: 10.13206/j.gjgS22120201
[5]	Faxing Ding, Luyu She, Linli Duan, Jianxiong Lei. Finite Element Analysis of Seismic Performance of Concrete-Filled Square Steel Tubular Column to Composite Beam Joint with Stiffening Ring Under High Axial Pressure[J]. STEEL CONSTRUCTION(Chinese & English), 2024, 39(1): 29-40. doi: 10.13206/j.gjgS23072801
[6]	Yan Gao Guochang Li Xiao Li, . Finite Element Analysis of Pure Bending Properties of Square Steel Tube-Wood-Concrete Members[J]. STEEL CONSTRUCTION(Chinese & English), 2024, 39(7): 38-46. doi: 10.13206/j.gjgS23110202
[7]	Zhijian Yang Wenzhi Zuo, . Finite Element Analysis on Axial Compressive Performance of RHHCFST Short Columns with Longitudinal Stiffeners[J]. STEEL CONSTRUCTION(Chinese & English), 2024, 39(7): 19-28. doi: 10.13206/j.gjgS23112901
[8]	Zhenhai Shi, Minglan Han, Yan Wang, Kuan Pang, Xu Wang. Analysis of Mechanical Properties of Joints and Frames with Cantilevered Beams Based on Joint Simplification Theory[J]. STEEL CONSTRUCTION(Chinese & English), 2023, 38(3): 24-33. doi: 10.13206/j.gjgS22120501
[9]	XING Zunsheng, YE Dongchen, ZHANG Zhihao, JIA Shangrui. Performance Analysis of Complex Cast Steel Joint in the Steel Roof of Hangzhou West Railway Station[J]. STEEL CONSTRUCTION(Chinese & English), 2023, 38(2): 1-7. doi: 10.13206/j.gjgS22120101
[10]	XU Yi-feng, ZHOU Li, YIN Chao, ZOU Qing-yu. Experimental Study on Axial Compression Behavior of Phosphogypsum-Filled Thin-Walled Square Steel Tube Stub Columns[J]. STEEL CONSTRUCTION(Chinese & English), 2023, 38(1): 21-28. doi: 10.13206/j.gjgS22042702
[11]	Jiansen Feng, Zexuan Sun, Yun Zou, Chengquan Wang. Finite Element Analysis of Axial Compression Behavior of Steel Tubular-Corrugated Steel Plate Confined Concrete Composite Column[J]. STEEL CONSTRUCTION(Chinese & English), 2023, 38(8): 14-21. doi: 10.13206/j.gjgS23041202
[12]	Zhaobing Ren. Nonlinear Performance Analysis of Steel Reinforced Concrete Beam Column Joints in Yinchuan Green Space Center[J]. STEEL CONSTRUCTION(Chinese & English), 2022, 37(9): 8-16. doi: 10.13206/j.gjgS22022202
[13]	ZHONG Chang-jun, SHEN Rui-li, WANG Hui. Finite Element Analysis of Cable Saddle’s Mechanical Performance Considering the Influence of Cast Steel Material Inhomogeneity[J]. STEEL CONSTRUCTION(Chinese & English), 2022, 37(11): 31-38. doi: 10.13206/j.gjgS20092001
[14]	Qingqing Xiong, Jiahui Qian, Zhihua Chen. Research Progress on Mechanical Properties of Concrete-Filled Steel Tube Members Under Corrosive Environment[J]. STEEL CONSTRUCTION(Chinese & English), 2022, 37(7): 1-19. doi: 10.13206/j.gjgs22041501
[15]	Yue Chen, Gang Wang, Xiaobin Hao, Guihai Yan. Evaluation of the Mechanism and Influence Parameters of the Core Concrete Debonding in the Concrete-Filled Steel Tube[J]. STEEL CONSTRUCTION(Chinese & English), 2022, 37(7): 20-30. doi: 10.13206/j.gjgS21110501
[16]	Pang Lin, Sun Guohua, Dong Jiaying, Liao Qianwen. Analysis on the Hysteretic Behavior of Special Truss Moment Frame Connections[J]. STEEL CONSTRUCTION(Chinese & English), 2021, 36(11): 14-21. doi: 10.13206/j.gjgS20081102
[17]	Qiang Xu, Haowen Liu, Wentao Qiao, Chao Wang. Finite Element Analysis on Seismic Behavior of A New Prefabricated Corrugated Steel Plate and Polyurethane Composite Shear Wall[J]. STEEL CONSTRUCTION(Chinese & English), 2021, 36(12): 1-8. doi: 10.13206/j.gjgS21051102
[18]	Zhenfeng Huang, Sumei Zhang, Lanhui Guo, Jie Chen. Performance of Dovetail Profiled Steel Concrete Sandwich Composite Members Subjected to Axial Compression[J]. STEEL CONSTRUCTION(Chinese & English), 2021, 36(4): 11-19. doi: 10.13206/j.gjgS21010601
[19]	Dong Liu, Yongjiu Shi, Xianglin Yu, Chengliang Tu. Parametric Analyses on Lateral Performance About Modular Composite Shear Wall with Double Steel Plates and Infill Concrete[J]. STEEL CONSTRUCTION(Chinese & English), 2020, 35(12): 43-49. doi: 10.13206/j.gjgS20120701
[20]	Zihan Jia, Xiantie Wang, Chuandong Xie, Jiaping Zhang, Yiwei Gu. Finite Element Analysis of Seismic Behavior of Self-Centering Concrete-Filled Square Steel Tubular Column-Steel Beam Joint with Slotted Energy Dissipation Plate[J]. STEEL CONSTRUCTION(Chinese & English), 2020, 35(12): 1-7. doi: 10.13206/j.gjgS20091601